Agent Industrial 2t gas boiler Singapore

Gas fired horizontal style and low pressure gas steam agent industrial 2t boiler singapore is designed specifically for the requirements of the commercial market and is available in sizes ranging from 1-20 tons for 0.7-1.6 MPa steam pressure.This type boiler also can use diesel oil,light oil or heavy oil as fuel.

Boiler plant equipment as three major important energy conversion device, fuel chemical energy into heat energy, and the pot was heated using thermal energy to become hot water having a sufficient quantity and a mass (steam temperature, steam pressure) steam turbine for use. The Anyang City, the power company to my company to buy a split 2 tons of steam condensing gas steam agent industrial 2t boiler singapore for supplying electricity demand. The WNS series split condensing boilers using advanced technology designed to greatly improve the thermal efficiency of the boiler, up to about 96%.

Primary air tube blockage is what causes? How to prevent? Reason: 1) blocked or coked-burner fire nozzle inlet is blocked portion of small oil gun and other debris. 2) too many impurities coal, powder machine speed is too high, the pulverized coal and primary air speed too low. 3) powder machine speed is too high, too much under the powder without timely blown away. 4) a low pressure (throttle open or not to open too small), can not take away meal. Precautions: 1) to the powder and the rotational speed of the unit load and adjust relevant primary pressure according to the powder not more than 700 rpm rotation speed, a wind speed of each holding 25 ~ 30m / s, the mixed primary air temperature was controlled at 180 to 250 ℃, a pressure depending on the load, depending on coal, in the range 2.5 ~ 3.8kPa. 2) find a wind speed is too low, the primary air temperature is lower than the normal value should be to lower the rotation speed corresponding to the normal to the powder of a primary air temperature and wind speed. 3) open, gas steam agent industrial 2t boiler singapore tank should be fully cut-off torch powder, the powder in the tube is blown accumulated powder. 4) Fire mouth clogged or coked should try to remove. What causes large vibrations induced draft fan? 1) motor bearings in oil, resulting in large vibration and bearing wear; 2) even when the shaft is mounted on the center not good; 3) induced draft fan stall surge; 4) anchor bolt loosening induced draft fan; 5) blade fouling or wear ,lost balance.

As the price of rice husk biomass fuels becomes more competitive, compared with traditional fuels such as coal, oil and gas, the demand for rice husk biomass power plant agent industrial 2t boiler singapores is steadily increasing. Subsequently, this has created a growing need for the manufacturing of boilers for these cleaner and more sustainable fuels. It is also widely used to handle the chaff, sawdust, wood wastes, bagasse and crushed straw, is a large rice mills, furniture factories, plywood factories, paper mills and vast rural areas agroforestry waste treatment, energy recovery, protection an energy-efficient boiler environment.