Energy Saving Factory Direct Supply gas fired boiler

6 tons adjusting a combustion gas steam energy saving factory direct supply fired boiler, normal combustion boiler three basic aspects of indicators include a uniform supply of the fuel, reasonable ventilation, adjustment the combustion. 1, to maintain the high temperature of the combustion chamber temperature of the upper layer is preferably in the 1100 ~ 1300 ℃, flame orange in color. Flame reddish color indicates that the amount is not enough to the wind, the color white indicates that excessive wind. It should be appropriately adjusted. 2, fuel ash to reduce ash content in the combustibles to be below 10%. 3, reducing the temperature of the boiler flue gas exhaust gas temperature should be controlled below 200 ℃. 4, holding furnace negative excess air boiler is 1.2 to 1.4, by adjusting the balance of the blowers to maintain the furnace pressure is -20 ~ -30Pa. 5, the thermal efficiency of the boiler to improve the thermal efficiency of the boiler should be kept above 60%. II. Combustion Adjustment 1, the amount of fuel to air required for combustion and the amount of a reasonable distribution. Ventilation should first increase the amount of fuel increases, it should first reduce the amount of fuel supply reduced ventilation. 2, the thickness of the seam and seam thickness configuration grate speed is 80 ~ 120mm grate speed at high, middle and low profile configuration of several commonly used methods:. 9a rapid combustion of thin seam b c thick seam in low combustion. 3 thick seam combustion speed, the segment with the wind blowing principle: burn promoting intermediate ends. That is, after the coal into the coal starts to warm up the shutter, fire line front arch, the primary combustion zone, the middle grate to burn the rear grate zone. Normal combustion conditions are: fuel from the coal at the beginning of the fire shutter 300mm, uniform flames, the fire bed formation, at the end of combustion from the end of the grate 300 ~ 500mm. 4. maintain proper furnace temperature to avoid coking. The fire bed to maintain the homogeneous combustion, to avoid burning fire bed obliquely. 6. The residence time of the fuel on the grate in less than 30 minutes.

"Thalia T7" The launch will greatly resolve hotels, supermarkets, enterprises and other energy problems and low nitrogen integration, and promote clean heating reform, promote the development of clean heating industry, the posture of the strong start another wave.

Oil gas IBR industrial samll energy saving factory direct supply fired boiler

IBR Coal &Wood Fired Boilers :

Damage to the performance of the reheater 1, a energy saving factory direct supply fired boiler leak alarm device audible signal; abnormal sound near 2, reheater, serious damage to the furnace clearly audible sound; 3, reheater pressure drop electric load; 4, the chamber pressure rises too vanes Yin automatic opening air tight large current rise induced draft fan; 5, damage to the tobacco-side temperature decreases, both flue gas temperature deviation increases.