Fully Automatic 6t oil fired steam boiler Cyprus

Boiler cleaning the necessity and significance of the boiler after a long run, the inevitable emergence of scale, corrosion problems, these problems are due to the generation of scale, so that the heat transfer deterioration, resulting in reduced efficacy boiler. It is difficult to achieve nominal evaporation; and since the heat transfer is deteriorated, such that the metal overheating, under pressure boiler, furnace tube bulge occurs even explode; poor thermal conductivity, so that the fuel consumption is increased, increased operating costs, boiler shortened life expectancy. Therefore, the boiler scale, should take the necessary cleaning methods. Of the boiler system operated at optimized state, it must be specialized chemicals treatment of boiler system water system: to remove scale, rust and anti-corrosion treatment: 1 chemical cleaning: adding a chemical cleaning agent to rust in the system , dirt, cleaning oil dispersion is discharged, reduced to clean metal surfaces; 2, routine maintenance: boiler scale inhibitor is added, to avoid rusting of metal, to prevent the crystalline precipitate calcium and magnesium ions. Boiler cleaning in two parts, part of convection boiler tubes, superheater tubes, air heaters, waterwall tubes scale, rust cleaning, i.e. water boiler water treatment, we used the final Li Jing Ling descaling operation, neutral cleaning technology cleaning operation, relatively low cost; cleaning of the part of the outer tube, i.e. the cleaning of the boiler furnace, we used high-pressure water jet cleaning technology, it is possible to achieve good results. 1, the cleaning operation may be neutral at neutral or weak alkalinity (pH 7-12) conditions, the water does not change the operation of the boiler a predetermined state index, do not stop cleaning, cleaning can reduce the loss caused by the stop, this is a the only signs of cleaning. 2, security theory and practice of running the boiler have proven non-erosive, washed acid-free cleaning under neutral conditions, the corrosion rate is less than the water washing of the corrosion rate of the metal, no corrosion damage to the metal. 3, non-toxic and pollution-free operation of the Spirit is a green cleaning products, boiler blowdown COD after its cleaning. BOD. The pH full compliance with national standards. 4, easy to use drugs added to the water supply can be, without a separate professionals, post operator can operate, it can be widely used. 5, a significant saving, the cleaning process in which water is the normal production water, unlike dispensing additional consumption pickling, passivation, and a large number of repeated washing of freshwater resources consumed. High pressure water jet cleaning technology uses water as the medium, so that the water system by special equipment to produce multi-beam, multi-angle, high-pressure water jets of different intensity. Internal cleaning object fouling, plugging, or be completely cut surface adhesion, crushed, pressed and washed in order to achieve complete cleaning. Whatever the fouling deposits, high pressure water jet cleaning device for cleaning, can be completely removed, which considerably metal color. It does not require chemicals, or corrosive flux, safety, and environmental protection. Boiler air preheater, waterwall, superheater, economizer heating surface and the like due to clogging of the exhaust gas temperature, boiler efficiency is lowered, increasing the wind electrical energy consumption; the fan will cause severe blockage afford pulling negative pressure oxygen furnace not enough, boiler forced outage. Using high pressure water jet technology, the cleaning effect is obvious. Equipment from high pressure water pump, water hoses, high pressure gun, special nozzle and other components. Cleaning process: water pressure via a high pressure pump to the 50 ~ 100Mpa, via line transferred to the system actuators work surface, forming a bundle of fine high-pressure water emitted from the nozzle with a high pressure water jet but powerful strike capability, which exit velocity up to 380m / s, the heating surface fouling rinse. The high pressure cleaning technology to clean, easy to adjust, cleaning equipment to be non-corrosive, non-polluting the environment, the effect is obvious characteristics, is an effective and a good way to save money and effort, especially suitable for solving air preheater clogging, severe coking furnace heating surface slagging problems. Generally reduce exhaust gas temperature of 4 to 12 degrees, the main improved reheat steam temperature of 0.5 to 5 degrees, to reduce electrical energy consumption for the wind, and early detection of creeping inflation, under scale corrosion risks, the unit safe and economic operation of very help.

There are several series of oil and gas fully automatic 6t fired steam boiler cypruss produced by ZG boiler, wns oil and gas steam boilers and szs steam boilers. These two series of boilers mainly use natural gas, petroleum and heavy oil as fuel. The boilers are medium and small capacity boilers, and there is no noise and no ash. The boiler has high automation and convenient operation. The oil and gas boiler is a kind of boiler suitable for the textile industry. A textile factory in Bangladesh has cooperated with Z ZG boiler to purchase two wns oil and gas steam boilers.

When the weather gets colder and colder, people will choose different ways of heating, one of which is more convenient is the fuel-fired boiler, but many people do not understand his use, so take a look at the following. Classification: fuel-fired boiler is a kind of boiler which uses diesel oil, waste oil and so on. Its overall structure and arrangement are similar to coal-fired boilers, and the common classification is mechanical and steam materialized. Features: the bottom of the oil-fired boiler is mostly made of the heat preservation bottom tilted to the back wall, which is the bottom of the heat preservation furnace, in order to obtain good combustion characteristics. This kind of boiler, for those who do not have a natural gas pipeline, also hope The oil-fired boiler is a good choice when the cost of normal operation of the boiler is low. The fuel-fired boiler is an important symbol of the progress of the times, in order to serve the human being well and further perfect according to the needs of the people.

Fangkuai Group has more than 60 independent intellectual property rights, advanced clean fuel boiler manufacturing technology, and jointly established a clean fuel boiler production, research and research cooperation base with Tsinghua University and Xi'an Jiaotong University. An enterprise with a R & D and test center for clean fuel boilers. The thermal efficiency of “Fangkuai” boilers can reach 107%, which has been included in the national special equipment energy-saving catalog. The company developed ultra-low nitrogen full premixed combustion condensing boilers and ultra low nitrogen emission fuel gas boilers, which are developed by the company using Ultran condensation technology.