12 bars natural gas fired boiler malaysia

Gas oil furnace gas consumption and related questions can automate operations: conducting oil furnace oil furnace gas this kind, it is also the product website and keywords, it is necessary to know and understand the subject, otherwise, can not be familiar with the site and its manufacturer. Therefore, in order to achieve this goal, the following will be introduced to the product description, so that we have to learn content, and thus, can be development and progress in their learning path. 12 000 kcal conducting oil furnace gas, if gas is natural gas which, then, the upper limit of the 12 bars fired boiler malaysia air consumption of natural gas, how much is? 200,000 kcal conducting oil furnace gas, if it is natural gas, then, the air consumption of the boiler gas limits are as follows: 200,000 divided by the gas heating value and thermal efficiency of the boiler, so as to obtain a particular value . If the boiler thermal efficiency is 94.8%, then, is the specific results of 24.8 cubic meters / h.

Using Ultraten wings condensation 12 bars fired boiler malaysia technology has greatly enhanced heat the heating rate; silicon alloy material design to achieve the depth of the condensing heat exchanger, high efficiency, high heat transfer speed. "APH the T7" ready to use the factory mode, the system design is simple and clear, i.e. security that is used, the best burner performance debugging the factory, the user can simply set up at the installation site, connected to gas, water, to a flue , it covers an area of ​​greatly reduced.

Boilers which are several general, in what is now the mainstream Why? 1, gas 12 bars fired boiler malaysia advantages: efficient, clean, environmentally friendly, without manual operation, only need to monitor, small footprint, no transportation fuel, no need to deal with soot, due to the combustion of natural gas free of impurities, without corrosion damage to the boiler and related accessories long boiler life, defined as 15 years, but basically long-term use. Is now mainstream boiler, natural gas is the environmental protection sector, the government vigorously promoted. Cons: You do not know how much that gas prices are calculated according to the calorific value and thermal efficiency, generally bituminous coal per ton of coal (according to 5500 kcal / kg) is approximately equal to 350 to 400 cubic meters of gas. Probably a little slightly more expensive than coal. (No transport, area, ash handling, labor, etc. into the calculation). 2, oil-fired boiler, advantages: substantially the same structure and properties of gas boilers. Disadvantages: higher cost of natural gas is 2 times the boiler, diesel transportation, storage more dangerous, accident-prone. And the domestic diesel supply is unstable, easily interrupted. 3, coal-fired boilers, the advantages: the economy. Disadvantages: 1, requires a lot of ash and coal yard area. 2, a boiler fireman for 4 to 8 people. 3, boiler room and coal yard is very dirty. 4, noise, emissions of dust, nuisance. 5, environmental protection departments often to check an inattentive, he was diagnosed with excessive emissions, maintenance shutdown, fine, very troublesome. 6, coal sulfur content are more severe corrosion of boiler, 10 to 15 years after the basic unusable. Summary: Due to high oil prices and supply unstable now, and now oil-fired boiler has been temporarily withdrawn from the market. Natural gas prices due to regional differences are very different, although you are not sure where the price of natural gas, but natural gas in most parts of the domestic coal is relatively expensive, (only in Sichuan, northwest of cheaper natural gas). Especially large industrial boilers, more fuel, the cost difference is more obvious. Coal-fired boilers to heavy air pollution, with the country on environmental issues more and more attention, more stringent emission requirements for coal-fired boilers, a lot of urban cities, has stopped the examination and approval procedures coal-fired boilers. It is recommended that, if your organization is not large tonnage production of boilers, installation of gas boilers or better, although with a little more than fuel costs, but in the actual operation of the process, you can save a lot of things, while saving area, the environment is clean.

5. The local site environment protection standard

For natural gas fired boiler, if it has requirements about NOx emission , for biomass boiler , the particular emission is very important , if local is strict with the dust emission ,as 30mg/nm3 ,maybe the boiler system will need bag filter , the price will enlarge .