Steam boiler must be shut down? For gas-fired boiler will be some companies: the higher cost of oil-fired boilers and electric heating boilers, many SMEs simply can not afford, the thermal efficiency of the boiler is too low, gas consumption often can not keep up. Many reasons why gas boiler known as the preferred place of the main gas boiler. In business consulting to some customers learned, after being forced to shut down the gas boiler, no steam, the company has only discontinued. In order to survive companies only replace the boiler, to select the gas-fired, oil-fired boiler, electric heating boiler and a biomass pellet boiler. Currently the market for natural gas boilers only major selection, analysis of the reasons is that gas-fired gas boiler is fully automatic, with no pollution. But in reality, many businesses faced to replace the boiler, gas pipeline did not pull in place, some companies simply do not have natural gas pipeline, ce asme china supplier oil boiler steam boiler price must be shut down? Gas boiler gas boiler, not to mention the natural ventilation. This is the biggest obstacle currently facing.

Boiler fire phenomenon, how to do 1, furnace pressure fluctuations or to limit and alarm. 2, no flame detector flame, flame flameless television display. 3, flue gas oxygen abnormal fluctuations. 4, steam pressure steam temperature dropped drastically. 5, furnace black, black smoke chimney. 6, the flue gas temperature is reduced. 7, MFT action, turbine trip, splitting the unit. Cause 1, the furnace combustion conditions organizations unreasonable, improper wind coal proportion. 2, the load is too low, unstable combustion conditions without oil combustion vote, or vote, although oil but not good combustion results. 3, cast oil, poor quality oil, oil spray gun is bad, low oil pressure, oil system failure. 4, poor coal quality, coal is too rough, the water is too large pulverized coal combustion adjustment is not timely. 5, the primary air temperature, air pressure is too low. 6, boiler MFT protection action. 7, a large area of ​​the furnace coke collapse, smashing off the flame. 8, severe water wall pipe explosion will blow out the flame. 9, all coal-fired condition, mill pulverizing system failure caused most or all trips. 10, a part of auxiliary machinery such as a fan, blower, fan, air preheater tripped, causing unstable furnace combustion conditions. 11, sootblowing properly, resulting in a large number of normal operation of the furnace ash effects of fire inspection of the boiler. 12, bottom seal damage. Treatment 1, the boiler fire, MFT should be action, otherwise manual MFT. 2, normal inspection device linkage linkage MFT, confirm that all fuel cut. 3. quickly identify the cause, try to eliminate the boiler can be re-ignition, the recovery unit operation. 4, when the mill started again after the trip, the trip must be the primary air tube mill full purge. 5, the MFT operation, checks, Fan normal operation, automatic furnace vent. 6, the MFT movement, check all the secondary purge air damper position is set, the total air volume is automatically adjusted to 30 ~ 40% BMCR sufficiently purged air volume. 7, the MFT operation, when the turbine is in a state disk drive, the disk drive must continue until the normal turbine eccentricity, before re turn red. 8, if temporarily unable to identify or eliminate the cause, restart and could threaten personal safety equipment, non-start. 9, processing according to the corresponding predetermined remaining MFT.

Tail gas boiler heating surface, promote energy conservation, ce asme china supplier oil boiler steam boiler price, make full use of surplus gas, iron and steel ring can be part of the No. 2 boiler recently implemented gas utilization upgrading the premise of low temperature corrosion does not occur. The transformation of the original two No. 2 Power Station Boiler 220 t / h circulating fluidized bed boiler, the transformation of 200 tons / hour gas-fired boiler. To reduce the cost, Shaoguan Iron & Steel ring portion can be modified in the original boiler equipment, removal coal system, discharging systems, dust removal systems, fuel systems; Lee used equipment including the original boiler water wall, drum, steel frame, platform escalators, tail shaft convection heating surface, steam systems, water systems and some electrical, instrumentation and other facilities, while adding the blast furnace, a coke oven gas in each system, the new blast furnace, coke oven gas mixing burner 4, the combustion of blast furnace gas device 4, a low-low pressure economizer, the boiler flue gas boiler guaranteed emissions compliance and four 10 kV high-pressure fan, part of the electrical and gas drainage, tail heating surface is not provided at a low temperature corrosion occurs meter facilities. No. 2 boiler after the upgrade, to ensure the boiler flue gas emissions standards and low temperature corrosion tail heating surface does not occur under the premise, as far as possible be able to mix more burning oven gas, surplus gas consumption, save energy and reduce environmental pollution.

The use of central heating hot water boiler is the best choice for winter heating in northern China. Shanxi Province is located in Chang Darrow Heating Co., Ltd. mainly provides heating and post-service maintenance of heating equipment, heating clients involved in enterprises and institutions, office buildings, residential housing and a variety of commercial and other entertainment venues. With the wide blue sky covered Battle of the project, China's gradual increase in the proportion of heating for cleaning, heating, Ltd. Dalong Chang respond positively to the call of national policy, high pollution intensity wishing previously used, low thermal efficiency of coal-fired boiler to replace the traditional use hot water boiler clean fuel. After comparing many boiler manufacturers, choosing the optimal selection, determined and professional cooperation parties do fast boiler fuel boiler cleaning equipment. Providing a fast side 35 MW gas tube hot water boiler (SZS35-1.6-Y.Q) according to their actual needs.